HVAC Repair & Replacement Cost in Beaumont, TX

What Beaumont pays for heating and cooling work

† Central AC replacement: High end reflects two-stage and variable-speed equipment, larger homes, and duct modifications; a standard-efficiency change-out on sound ductwork lands in the lower half.

† Furnace replacement: Electric furnaces sit at the low end; gas furnaces run $3,800 to $10,000 in most guides, and high-efficiency condensing units push past the high end.

† Heat pump installation (air-source): Sources disagree widely (>3x): contractor-network averages (Angi, Bob Vila, Today's Homeowner) cluster near $6,000 for a like-for-like change-out, while HomeGuide, This Old House, and Carrier quote $10,000 to $25,000 for higher-efficiency and cold-climate systems. Range widened to cover both.

† Ductwork replacement: Whole-home replacement in a 1,500 to 2,500 sq ft house; replacing a few runs costs a fraction, and retrofitting ducts into a home that never had them runs above the high end.

After Rita, Ike, and Harvey: storm damage or wear?

Southeast Texas has taken repeated hurricane hits, and a Beaumont condenser sits outside in all of them. Jefferson County reports in 2016–2025 included wind gusts as high as 110 mph and 9 tornadoes. When a storm throws a tree, a fence section, or roofing debris into the outdoor unit, or hail crushes its coil, that is the kind of sudden damage a homeowners policy usually pays for, less the deductible. Lightning and fire count the same way.

What a policy excludes is the failure most Beaumont systems actually have: a compressor, motor, or coil that wears out after years of damp heat. Adjusters see both after a storm, and an old unit that stops running the week after a hurricane is not automatically a storm claim. A technician's written note on the cause of failure, with photos taken before anything is moved, is what separates the two. Water damage from storm flooding raises separate coverage questions, so ask your agent which policy, if any, applies rather than assuming. Equipment under manufacturer coverage may get parts paid, rarely labor, and a home warranty plan, a service contract rather than insurance, is the product sold for breakdowns.

What the Port Arthur station says about Beaumont

The climate normals for Beaumont come from Port Arthur Southeast Texas Airport, 19 km away toward the coast. It counts 3,076 cooling degree days a year (9th on the index), 93 days at 90°F or above, and a July high averaging 93°F. Days at 100°F barely register, at 1 a year. The load here comes from duration and humidity rather than extreme peaks, and zone 2A carries an "A" for its moist air.

That humidity sets the terms for a replacement. A unit sized too large satisfies the thermostat before it has pulled moisture out of the air, which leaves a cool, damp house. Ask every bidder for a Manual J load calculation that includes the latent (moisture) load. Two-stage or variable-speed equipment, which runs longer at low output and dries the air better, sits in the upper part of the $4,200–$12,500 central AC row.

League clay under the condenser pad

Jefferson County has some of the most expansive soil on this index: NRCS rates 59% of its rated land very limited by shrink-swell, 3rd of 33, led by the League, Beaumont and Labelle series. The Beaumont clay formation, which shares the city's name, is part of that picture. Soil that swells and shrinks moves a slab, and it moves the outdoor unit's pad too.

A condenser that tilts as its pad settles can strain the refrigerant lines where they leave the unit and, if it leans far enough, affect how the compressor handles oil. Check that the pad still sits level at each $100–$350 maintenance visit. Releveling or resetting a pad costs little next to a leak repair in the $150–$700 row or a $1,000–$3,100 compressor.

Labor priced close to Houston

Beaumont's labor factor, 1.04, is the 2nd highest of 33 on the index; local construction pay averages $1,677 a week, 8% above the national $1,555. Houston is at 1.05, while Tyler, well to the north, is at 0.89. The middle job on this page is $3,100; in Tyler it is $2,700.

After a regional storm, demand for HVAC crews jumps all at once. If your system still runs, there is rarely a reason to sign a replacement contract in that first week. A second bid, taken once schedules calm down, is the best protection against storm-week pricing.

A replacement built for wet heat and mild winters

With 1,262 heating degree days and a January low averaging 44°F, heating is a small job in Beaumont. A standard heat pump covers it and usually costs less than a new air conditioner plus a new furnace; the wide $4,400–$15,600 heat pump row reaches its top only for cold-climate units that a Gulf Coast house does not need.

Since 2025, new systems use R-454B or R-32 refrigerant, and a new outdoor unit needs a matching indoor coil. Matching R-410A condensers are harder to source than before the switch, so a storm-wrecked condenser on an older system often turns into a new coil and condenser, or a full system. The minimum efficiency for a new split AC in the Southeast region is 14.3 SEER2.

Beaumont AC and storm-damage questions

Nearby & related